|
INNOVATIVE
CHEMICAL CORPORATION
711
NORTHLAND AVENUE
BUFFALO,
NEW YORK 14211
PHONE:
716-883-4000 FAX:
716-892-1171
MATERIAL
SAFETY DATA SHEET
--------------------------
MAY
BE USED TO COMPLY WITH OSHA’S HAZARD COMMUNICATION STANDARD, 29 CFR
1910.1200. STANDARD MUST BE CONSULTED FOR SPECIFIC REQUIREMENTS.
---------------------------------------------------------------------
MANUFACTURER’S
NAME:
PREPARED BY
WORLD
MARKETING OF AMERICA, INC.
QC Supervisor 10/18/99
---------------------------------------------------------------------
SECTION
I-IDENTIFICATION
---------------------------------------------------------------------
TRADE
NAME:
PRODUCT CODE:
KERO
KLEAN
IC037
DOT
CLASS:
FLAMMABLE
LIQUID
CHEMICAL
NAME:
MIXTURE
---------------------------------------------------------------------
SECTION
II-HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
---------------------------------------------------------------------
HAZARDOUS
COMPONENTS
CAS #
OSHA
PEL
ACGIH TLV
METHYL
ALCOHOL
67-56-1
250 PPM
250 PPM
ALL
OTHER COMPONENTS ARE CONSIDERED NON-HAZARDOUS PER OSHA 29CFR 1910.1200
PLEASE
NOTE THAT THE CHEMICAL IDENTITY AND PERCENT COMPOSITION OF SOME OR ALL OF
THE ABOVE HAZARDOUS INGREDIENTS IS CONFIDENTIAL BUSINESS INFORMATION AND
IS BEING WITHHELD AS PERMITTED BY 29CFR 1910.1200 AND VARIOUS STATES RIGHT
TO KNOW LAWS.
----------------------------------------------------------------------
SECTION
III-PHYSICAL/CHEMICAL CHARACTERISTICS
----------------------------------------------------------------------
BOILING
POINT:
147 F
SPECIFIC
GRAVITY (H20=1):
0.80
VAPOR
PRESSURE (MM Hq):
47.300 mmHG @ 60 F
MELTING
POINT:
ND
VAPOR
DENSITY (AIR=1):
ND
EVAPORATION
RATE (BUTYL ACETATE=1):
2.1 (N=BUTYL ACETATE)
SOLUBILITY
IN WATER:
SOLUBE
%
VOLATILE BY WEIGHT:
ND
WEIGHT
(LB/GAL):
6.65
%
SOLIDS:
ND
VISCOSITY:
(BROOKFIELD) ND
PH:
ND
APPEARANCE
AND ODOR:
CLEAR LIQUID, PINE ODOR
----------------------------------------------------------------------
SECTION
IV-FIRE AND EXPLOSION HAZARD DATA
----------------------------------------------------------------------
FLASH
POINT (TAG CC)
54 DEG. F.
LEL OEL
6.0
36.0
EXTINGUISHING
MEDIA:
CO2, DRY CHEMICAL. FOAM.
SPECIAL
FIRE FIGHTING PROCEDURES:
S.C.B.A. & BUNKER GEAR RECOMMENDED.
UNUSUAL
FIRE AND EXPLOSION HAZARDS:
TOXIC FUMES, GASES OR VAPORS MAY EVOLVE ON BURNING.
-----------------------------------------------------------------------
SECTION
V-REACTIVITY DATA
-----------------------------------------------------------------------
STABILITY:
STABLE
CONDITIONS
TO AVOID:
KEEP AWAY FROM HEAT, SPARKS OR OPEN FLAME. KEEP CONTAINERS TIGHTLY CLOSED, WASH HANDS AFTER HANDLING.
INCOMPATIBILITY
(MATERIALS TO AVOID):
ALKALIS, STRONG OXIDIZING AGENTS, ACIDS, AMINES AND CHLORO
COMPOUNDS.
HAZARDOUS
DECOMPOSITION BYPRODUCTS:
CO, CO2.
HAZARDOUS
POLYMERIZATION:
WILL NOT OCCUR.
-----------------------------------------------------------------------
SECTION
VI-HEALTH HAZARD DATA
-----------------------------------------------------------------------
ACUTE
HEALTH HAZARDS:
INGESTION MAY CAUSE RED BLOOD CELL HEMOLYSIS AND POSSIBLE LIVER AND
KIDNEY DAMAGE.
CHRONIC
HEALTH HAZARDS:
MAY CAUSE CHRONIC HEALTH EFFECTS BASED ON DATA WITH LABORATORY
ANIMALS, (SEE ABOVE).
CARCINOGENICITY:
UNKNOWN
SIGNS
AND SYMPTOMS OF EXPOSURE
EYES:
VISUAL IMPAIRMENT (INCLUDING BLINDNESS)
DERMAL:
IRRITATION, DEFATTING, REDNESS.
INHALATION:
MAY CAUSE DIZZINESS, HEADACHES, NAUSEA, AND VOMITING.
INGESTION:
NAUSEA, VOMITING, ABDOMINAL CRAMPS, AND IRRITATION OF THE
GASTROINTESTINAL LINING.
EMERGENCY
AND FIRST AID PROCEDURES
EYES:
FLUSH WITH LARGE AMOUNTS OF COOL WATER FOR 15 MINUTES.
IF IRRITATION PERSISTS, CONTACT A PHYSICIAN.
DERMAL:
WASH WITH SOAP & WATER AND RINSE THOROUGHLY.
REMOVE CONTAMINATED CLOTHING.
INHALATION:
REMOVE PERSON TO FRESH AIR. IF
BREATHING IS DIFFICULT, ADMINISTER OXYGEN, GET MEDICAL ATTENTION.
INGESTION:
GIVE CONSCIOUS PERSON WATER OR MILK TO DILUTE. INDUCE VOMITING.
----------------------------------------------------------------------
SECTION
VII-PRECAUTIONS FOR SAFE HANDLING AND USE:
----------------------------------------------------------------------
STEPS
TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
LARGE
SPILLS:
PICK UP AS MUCH AS POSSIBLE AND PLACE IN CONTAINERS FOR DISPOSAL.
RESIDUAL LIQUID CAN BE ABSORBED ON INERT MATERIAL.
SMALL
SPILLS:
SAME AS FOR LARGE SPILLS.
WASTE
DISPOSAL METHOD:
CONSULT LOCAL, STATE & FEDERAL REGULATIONS.
----------------------------------------------------------------------
SECTION
VIII-CONTROL MEASURES
----------------------------------------------------------------------
RESPIRATION
PROTECTION (SPECIFY TYPE):
USE NIOSH/MSHA APPROVED COMBINATION ORGANIC VAPOR AND HIGH
EFFICIENCY FILTER CARTRIDGE IN HIGH CONCENTRATION AREAS.
VENTILATION:
GOOD AIR CIRCULATION, EXHAUST VENTILATION FOR MISTS OR VAPORS.
PROTECTIVE
GLOVES:
NON-PERMEABLE BUTYL.
EYE
PROTECTION:
GOGGLES, OR FULL FACE SHIELD IS RECOMMENDED.
OTHER
PROTECTIVE CLOTHING OR EQUIPMENT:
SUFFICIENT TO PROTECT AGAINST PROLONGED SKIN CONTACT.
WORK/HYGIENIC
PRACTICES:
ALWAYS WASH HANDS & FACE BEFORE CONSUMING FOOD OR BEVERAGES OR
WHENEVER CONTACT ON THE SKIN.
----------------------------------------------------------------------
SECTION
IX-NOTES: NOTE TO PHYSICIAN:
----------------------------------------------------------------------
NONE.
HAZARD RATING
HEALTH
1
FLAMMABILITY
3
REACTIVITY
0
----------------------------------------------------------------------
THE
INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE.
HOWEVER, NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY
OF THIS DATA OR THE RESULTS TO BE OBTAINED FROM THE USE THEREOF.
VENDOR
ASSUMES NO RESPONSIBILITY FOR INJURY TO VENDEE OR THIRD PERSON PROXIMATELY
CAUSED BY THE MATERIAL IF REASONABLE SAFETY PROCEDURES ARE NOT ADHERED TO
AS STIPULATED IN THE DATA SHEET. ADDITIONALLY,
VENDOR ASSUMES NO RESPONSIBILITY FOR INJURY TO VENDEE OR THIRD PERSONS
PROXIMATELY CAUSED BY ABNORMAL USE OF THE MATERIAL EVEN IF REASONABLE
SAFETY PROCEDURES ARE FOLLOWED. FURTHERMORE,
VENDEE ASSUMES THE RISK IN HIS USE OF THE MATERIAL.
|
